Defect Investigations - Search Results

Navigate:   ODI Home   »   Defect Investigations   »  Search »  Results List

Search Results   Report Date : February 9, 2010 at 10:43 PM NHTSA Action Number : PE04077 N/A NHTSA Action Number : PE04077 NHTSA Recall Campaign Number : N/A Make / Models :         Model/Build Years:          NISSAN / MURANO     2003-2004 Manufacturer : NISSAN NORTH AMERICA, INC. Component : ELECTRICAL SYSTEM ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR Date Investigation Opened : November 19, 2004 Date Investigation Closed : March 25, 2005 Summary: ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE. ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED. DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI¿S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES. ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION. HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE. THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION. Check to Request Research. Submit below.